Product ID:LXP-3014 BASE,YELLOW 33538,POLYURETHANE
MSDS Date:01/01/1985
FSC:8010
NIIN:00-181-7090
Kit Part:Y
MSDS Number: BDGHH

DEFT CHEMICAL COATINGS

17451 VON KARMAN AVE
IRVINE, CA 92714-6205
US

Emergency Phone: 714-549-8911

Cage: EO418

DEFT, INC.

IRVINE, CA 92614 US

Telephone: 949-474-0400

Cage: 33461

METHYL ETHYL KETONE (2-BUTANONE) (MEK) (SARA III)

CAS: 78-93-3

RTECS: EL6475000

Fraction By Weight: 30.0%

OSHA PEL 200 PPM/300 STEL

ACGIH TLV: 200 PPM/300STEL 9192

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

2-ETHOXYETHYL ACETATE (CELLOSOLVE ACETATE) (EGEEA)

CAS: 111-15-9

RTECS: KK8225000

Fraction By Weight: 10.0%

OSHA PEL S,100 PPM

ACGIH TLV: S, 5 PPM; 9192

N-BUTYL ACETATE (SARA III)

CAS: 123-86-4

RTECS: AF7350000

Fraction By Weight: 10.0%

OSHA PEL 150 PPM/200 STEL

ACGIH TLV: 150 PPM/200STEL;9192

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

LEAD CHROMATE (OSHA PEL FOR LEAD FROM 29CFR

CAS: 7758-97-6

RTECS: GB2975000

Fraction By Weight: 20.0%

OSHA PEL 0.05 MG/M3 (PB)

ACGIH TLV: 0.05MG/M3(CR)A2;8990

DIBUTYL TIN DILAURATE (AS TIN)

CAS: 77-58-7

RTECS: WH7000000

Fraction By Weight: 0.05%

OSHA PEL S, 0.1 MG/M3

ACGIH TLV: S, 0.1 MG/M3; 8990

Effects of Overexposure:EYES:MODERATE IRRIT;SKIN:POSSIBLE IRRIT BY
SOLVENTS;INH:SOLVENT VAPORS CAN CAUSE IRRIT OR NARCOSIS

First Aid:SKIN:WIPE OFF WTH A RAG THEN THOROUGH RINSING W/H*2O &
WASHING W/MILD SOAP AND WATER;EYES:FLUSH W/WATER FOR AT LEAST 10
MIN & CONSULT AN EYE PHYSICIAN;INH:REMOVE TO FRSH AIR.GIVE
CPR/OXYGEN IF NEEDED.

Flash Point:28F(-2.2C)-OC
Lower Limits:UNK
Extinguishing Media:CO*2,DRY CHEM,FOAM
Fire Fighting Procedures:DO NOT USE H*2O STREAM ON FIRE.H*2O SPRAY/FOG
IS MORE EFFCTV
Unusual Fire/Explosion Hazard:CAUTION AGAINST APPLICATION TO HOT
SURFACES & USE IN AREASWHERE SOURCES OF IGNITION MAY BE PRESENT.

Spill Release Procedures:EVACUATE UNPROTECTED PERSONS.ELIM IGN
SOURCES.USE SAFETY EQUIP.VENTLATE AREA.STOP LEAK W/O RISK.ABSORB SM
SPILL W/OIL ABSORBNG COMPD/RAGS;DIKE LG SPILL.PUMP LIQ TO SALVAGE
TANK.SHOVEL UP RESIDUE INTO COVR DRUMS;PER MFR,FLUSH AREA W/LG AMO
H*2O

Handling and Storage Precautions:STORE IN COOL,DRY WELL VENTILATED,LOW
FORE RISK AREA.KEEP CONTRS TIGHTLY CLOSED.KEEP AWAY FM HEAT,SPARK
OR OPENFLAME.
Other Precautions:AVOID PROLONG4ED INHALATION OF VAP.PER MFR,WATER
SPRAY OR FOG CAN BE USED EFFECTIVELY ON FIRE AND TO COOL HEAT/FIRE
EXPOSED CONTRS.

Respiratory Protection:GOOD VENTILATION IS NEEDED.HOWEVER USE NIOSH
APPRVD SCBA FOR PAINTS.
Ventilation:USE ADEQUATE VENTILATION USING EXHAUST FAN.
Protective Gloves:IMPERVIOUS
Eye Protection:SAFETY/CHEM GOGGLES.
Other Protective Equipment:AS REQD TO PREVENT PROLONGED OR REPEATED
CONTACT.
Supplemental Safety and Health
TWO PART KIT. THIS IS BASE; ALSO CONTAINS; 0.5% DISPERSNG AGENT,
<0.5% ANTI-MAR AGENT & 29% NON-AQUEOUS SOLUTION, HAZARD UNKNOWN
UNIDENTIFIED; ED; SPEC REF NAI-1290. KEY1:F3.

HCC:F2
Boiling Pt:B.P. Text:175-329F
Vapor Density:>1.0
Spec Gravity:0.9544
Evaporation Rate & Reference:<1(SLWR THAN ETHR)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:YELLOW PAIN,ODOR PLEASANT PUNGENT.
Percent Volatiles by Volume:74.3

Stability Indicator/Materials to Avoid:YES
OXIDIZING & CORROSIVE MATERIALS.
Stability Condition to Avoid:SOURCE OF IGN,SPARK,HEAT AND OPEN FLAME

Waste Disposal Methods:KEEP IN CLOSED CONTRS PENDING DISPOSAL.MFR
SUGGESTED,DISPOSE IN TIGHTLY CLOSED CONTAINERS & FINALLY DISPOSE BY
SANITARY LANDFILL IAW APPLICABLE REGS;HANDLE & DISPOSE IN FULL
COMPLIANCE W/ALL FED,STATE ,& LOCAL REGULATIONS CONCERNING WASTE
DISPOSAL

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.